ZX210W-5A WHEELED EXCAVATOR TECHNICAL MANUAL TROUBLESHOOTING
Service Manual consists of the following separate Part No.
Technical Manual (Operational Principle) : Vol. No.TOLCDE0-EN
Technical Manual (Troubleshooting) : Vol. No.TTLCDE0-EN
Workshop Manual : Vol. No.WLCDE0-EN
Engine Manual : Vol. No.ETDCY0-EN, EWDCY-EN
The Attached Diagram List
The following diagrams are attached to this manual.
Circuit_1
1. ELECTRICAL CIRCUIT DIAGRAM
CONNECTORS
2. CAB HARNESS
ENGINE HARNESS
3. FLOOR HARNESS
4. AIR CONDITIONER CIRCUIT DIAGRAM
AIR CONDITIONER HARNESS
5. PUMP HARNESS
CHASSIS HARNESS
6. LEFT CONSOLE HARNESS
RIGHT CONSOLE HARNESS
7. MONITOR HARNESS
8. GSM (MOBILE COMMUNICATION TERMINAL) HARNESS
ENGINE STOP SWITCH HARNESS
9. KEY SWITCH HARNESS
PILOT SHUT-OFF SOLENOID VALVE HARNESS
10. REARVIEW CAMERA HARNESS
BLADE/OUTRIGGER HARNESS
11. HYDRAULIC CIRCUIT DIAGRAM (MONOBLOCK BOOM) (FULL OPTION)
Circuit_2
1. AUXILIARY FLOW COMBINER HARNESS
AIR SUSPENSION, HEATER SEAT HARNESS
2. FUEL SOLENOID PUMP SWITCH HARNESS
3. BOOM BOTTOM PRESSURE SENSOR HARNESS
WORK LIGHT (BOOM) (MONOBLOCK BOOM) HARNESS
4. FRONT HEADLIGHT (CAB) HARNESS
WORK LIGHT (CAB) (FRONT 1) HARNESS
5. WORK LIGHT (CAB) (FRONT 2) HARNESS
WORK LIGHT (CAB) (REAR) HARNESS
6. WORK LIGHT (CAB) (REAR) SWITCH HARNESS
12 V POWER HARNESS
7. LICENSE PLATE LIGHT HARNESS
LICENSE LIGHT HARNESS
8. PIN JACK HARNESS
PIN JACK SUB HARNESS
SECTION AND GROUP CONTENTS
SECTION 4 OPERATIONAL PERFORMANCE TEST
Group 1 Introduction
Group 2 Standard
Group 3 Engine Test
Group 4 Machine Performance Test
Group 5 Component Test
SECTION 5 TROUBLESHOOTING
Group 1 Diagnosing Procedure
Group 2 Monitor
Group 3 e-Service
Group 4 Component Layout
Group 5 Troubleshooting A
Group 6 Troubleshooting B
Group 7 Air Conditione
